MACHINERY

Don't forget the stubble this harvest

Growers are being urged to carefully manage stubble this harvest.

Staff writer

This article is 3 years old. Images might not display.

The Department of Primary Industries and Regional Development (DPIRD), in Western Australia, has harnessed a range of harvesting information and advice, as well as stubble management strategies including how to mitigate the risk of soil erosion.

DPIRD recommends landholders should maintain at least 40 per cent standing stubble, of which at least 30 per cent should still be anchored by the beginning of autumn.

Retaining stubble from dense crops protects the paddock surface from wind erosion, while also improving soil moisture retention, organic matter, weed and disease control, crop emergence and nutrient availability.

Research scientist Glen Riethmuller said the key to a good harvest this season was to cut stubble as long as possible, without leaving grain behind, and spread the chaff and straw evenly across the paddock to provide ground cover for wind protection.

Riethmuller said the cut height would be imperative in this season's heavy stubbles to drive harvester capacity and reduce fuel consumption.

"If using a weed seed destructor, it could be important to adjust the cutterbar height to just below the weed seed heads, so the weed seeds are captured and thrown into the destructor to reduce the weed seed risk for next year," Riethmuller said.

"This may be above the normal 'drink can height' but will help the harvester to chew through the crop more quickly, reducing the load and fuel cost."

Another option to boost header capacity is to adjust a chopper, which Riethmuller said could be adapted to further reduce the power needed but still provide ground cover.

"Growers can pull out every second knife in the chopper to reduce the load in a big crop, which may improve performance while still leaving stubble long enough for wind protection," he said.

A strategy for growers who employ controlled traffic farming systems is harvesting on an angle to the seeding direction to distribute the straw and chaff across the tramlines to provide more even ground cover.

Alternatively, if the soil is dry and the straw spreader cannot throw the full width, harvest half a front width off the tramline to distribute the straw more evenly from previous harvests, which may also help seeding the following season.

Growers with crops that were damaged by frost and those with lupins are reminded to keep headers clean from dust to reduce the risk of header fires.

"Crops that have been affected by frost tend to produce a lot of dust, as do lupin crops that experience a short, sharp finish to the season," Riethmuller said.

To see DPIRD's latest harvest tips, visit: https://bit.ly/39ZuKvB

A growing series of reports, each focused on a key discussion point for the farming sector, brought to you by the Kondinin team.

A growing series of reports, each focused on a key discussion point for the farming sector, brought to you by the Kondinin team.

editions

Research Report: Sealable Storage Options (August 2025)

Kondinin Group researchers in collaboration with the GRDC Grain storage extension team test dozens of gas-tight sealable grain storages to Australian Standard AS2628-2010 identifying best and worst features in the ultimate grain storage buyers guide.

editions

Research Report: Cordless Impact Wrenches (July 2025)

Six battery-powered impact wrenches were bench tested in this month's Research Report, focusing on their ability to get nuts done up and undone.

editions

Research Report: Mouse Bait Applications (June 2025)

Mice remain a significant issue for cropping regions and the June Research Report, supported by an investment from the Grains Research and Development Corporation, brings together the latest research and practical recommendations for bait spreading and machinery performance to help growers improve mouse control strategies.

editions

Research Report: Farm Labour (May 2025)

Farm labour, whether temporary, casual, contract or permanent staff, is an essential part of agriculture. This Research Report provides insights to help better source and manage one of the farm’s most valuable assets – its people.